Making Of Ceramic Membranes For Wastewater Treatment Of Hydrocarbon
Volume 2 - Issue 2, February 2018 Edition
[Download Full Paper]
Author(s)
Mansoor Kazemimoghadam
Keywords
hydrocarbon, membrane, ceramic, waste, treatment
Abstract
Various types of liquid hydrocarbons are used.One of the problems of these hydrocarbons is the formation of hydrocarbon waste. Wastewater polluting the environment and should remove hydrocarbon contaminants before discharge into the environment or reduced. Different methods of physical, chemical, biological and thermal treatment of this type of wastewater is not a good performance.According to membrane technology for wastewater treatment, in this study, two layers ceramic membrane was made.The membrane consists of two base layers and the active layer was made. On the basis of various parameters such as percent alumina to kaolin, the baking temperature and pressure of hydraulic presses for making the base layer were examined. The effect of these parameters on exudate flux and porosity of the membrane was determined Created. The active layer of alumina was synthesized at 550 C on the base. The results showed that the supports of calcined in 1200 C include of 60% alumina and 200 bar pressure is good strength.At this condition, The porosity of the support is 41% and water permeability flux is 746 Kg/m2.hr. The performance of the membrane to remove waste oil to 88 per cent. The built-in membrane performance compared to polymeric membranes showed better performance.
References
[1]. Ebrahimi, M.; Shams. K. "Characterization and application of different ceramic membranes for the oil-field produced water treatment." Desalination. 2009, 245, 533–540.
[2]. Ebrahimi, M.; Willershausen, K. "Investigations on the use of different ceramic membranes for efficient oil-field produced water treatment." Desalination. 2010, 250,991–996.
[3]. Geno, S.; Lehman, Li. "Application of ceramic membranes with pre-ozonation for treatment of secondary wastewater effluent." water research. 2009, 43, 2020 – 2028.
[4]. Hua, F.; Tsang, Y."Performance study of ceramic microfiltration membrane for oily wastewater treatment." Chemical Engineering Journal. 2007, 128, 169–175.
[5]. Salahi, A.; Mohammadi, T.; Rahmat Pour, A.; Reader, F. "Oily wastewater treatment using ultrafiltration." Desalination and Water Treatment. 2009, 6, 289–298.
[6]. Barredo-Damas, S.; Alcaina-Miranda, M. "Ceramic membrane behavior in textile wastewater ultrafiltration." Desalination. 2010, 250, 623–628.
[7]. Chakrabarty, B.; Ghoshal, A.; Purkait, M. "Ultrafiltration of stable oil-in-water emulsion by polysulfone membrane." J. of Mem. Sci. 2008, 325, 427–437.
[8]. Ghidossi, R.; Veyret, D. "Ferry oily wastewater treatment." Separation and Purification Technology, 2009, 64, 296–303.
[9]. Masuelli, M.; Marchese, J. "SPC/PVDF membranes for emulsified oily wastewater treatment." J. of Mem. Sci. 2009, 326, 688–693.
[10]. Yusuf, W.; Wahyunanto, A. "Degumming of Corn-oil for Biodiesel Using a Tubular Ceramic Membrane."; Procedia Chemistry. 2014, 9, 210–219.
[11]. Goran, T.; Mile, S. "Clarification of red raspberry juice using microfiltration with gas backwashing: A viable strategy to maximize permeates flux and minimizes a loss of anthocyanins." Food and Bio products Processing. 2013, 91, 473–480.
[12]. Xianfu, C.; Yuqing, L. "Yawei Lu A facile nanoparticle doping sol–gel method for the fabrication of defect-free nanoporous ceramic membranes."; Colloids and Interface Science Communications.2015, 5, 12–15.
[13]. Jia, X.; Chia-Yuan, C. "Congjie Gao Comparison of approaches to minimize fouling of a UF ceramic membrane in filtration of seawater."; Chemical Engineering Journal.2013, 223, 722–728.
[14]. Lee, M.; Wu, Z.; Li, K. "Advances in ceramic membranes for water treatment.": Advances in Membrane Technologies for Water Treatment, 2015, A volume in Woodhead Publishing Series in Energy, 43–82 .
[15]. Laura, D.; MarÃa, M. "Ceramic membrane filtration of organic compounds: Effect of concentration, pH, and mixtures interactions on fouling." Separation and Purification Technology. 2013, 118, 762–775.
[16]. Yina, N.; Zhaoxiang, Z. "Weihong Xing Ceramic membrane fouling and cleaning in ultrafiltration of desulfurization wastewater."; Desalination. 2013, 319, 92–98.
